2003 Bmw 330i Zhp
09-07-2010 | 08:57 AM
#33
Bro'd Out
Joined: Jul 2003
Posts: 11,674
Likes: 0
From: Capital of the South
Re: 2003 Bmw 330i Zhp
ZHP - Performance Package
The performance package was available on 2003-2005 330 sedans (330i) and 2004-2006 330 coupes and convertibles (330Ci/330Cic). In 2003, it was only available with the 6-speed manual transmission and WITHOUT the premium package. In 2004, all performance package cars were also available with the automatic (steptronic) transmission as well as the premium package.
Obviously, the Performance Package is a level above the Sport Package, so they're not available together.
Per the BMW press release, this package included the following changes. However, many of these claims have been found to be misleading:
Engine mods (new camshafts, electronics, & lighter flywheel) for 10HP & 8 ft/lb of torque increase & 6800 max RPM (from 6500).
6 speed short throw shifter (for manual transmission equipped cars)
3.07:1 Final drive ratio w/ manual trans instead of the standard 2.91:1. Convertibles retained the already installed 3.07 ratio.
Max Speed Limiter set to 155 mph (instead of 128)
New M suspension, more "sporty" than standard sport package:
Firmer springs (front +6%, rear +8%)
There are no "ZHP" specific springs. The same springs are used for comparably equipped 330's for both the ZSP and the ZHP. In both cases, the spring rate for the post 4/01 build ZSP and ZHP is believed to be slightly less than that of the pre-4/01 ZSP
Firmer shocks (Jounce: front +50%, rear +20%), (Rebound: front +35%, rear -8%)
ZHP does use different dampers than the ZSP. There is a shortage of shock dyno data, but based on the SACHS damping parameter values it is believe the jounce damping is the same but rebound damping is stiffer on the ZHP. Pre-4/01 sport package cars had similar damping values to the ZHP but used the higher grade SACHS "Advantage" dampers rather than the "Super Touring" model
Larger diameter anti-roll bars: 23.5 mm front (v. 23.0), 18.5 mm rear (v. 18.0)
Sway bar diameters are 23.5 mm and 18.0 mm for all post 4/01 build 330's. There is no 18.5 mm rear sway bar offered by BMW for the E46.
More rigid forward bushings
Front Control arm bushings are the same ZHP/ZSP
ZHP control arms are different and use a stiffer ball joint
Lower ride height by 15 mm (.6 inches) utilizing shorter auxiliary springs
Since both the ZSP and ZHP use the same springs, they have the same ride height. Both are 15mm lower than a non-sport E46
-.5 degrees of camber (for a total of -1.1 degrees)
Alignment settings are the same ZSP and ZHP
BMW M exterior trim elements (front & rear fascia, side sills, & trunk lid spoiler)
Special exterior trim: Anthracite (charcoal) headlight & foglight surrounds, High-Gloss
Shadowline (black gloss) trim
Large diameter stainless steel dual exhaust outlets
Extra thick Alcantra steering wheel (later switched to perforated leather)
ZSP Sport Seats
Alcantra & cloth upholstry to replace leatherette and standard trim (leather still optional)
Choice of "Black Cube" or "Silver Cube" interior trim
Anthracite headliner
Red needles on the instrument cluster
Unique 18" Wheels (style 135M), 18x8.0" front, 18x8.5" rear
Wider Tires: 225/40ZR-18 in front and 255/35ZR-18 in the rear.
Quicker steering rack ratio. 13.7:1 versus 15.4:1
All post 4/01 330's use the same part number steering rack. The ratio of this rack has not been confirmed, but it is believed to be different from that used on the 325's
you can cross of sport package. and from the best of my knowledge they all came with heated seats. as for premium package. i don't even know what that is.
if you're on KBB, the price he has this car is at the highend of the KBB value. mine is 2003 with 109k and it said my asking price would be around 12k (in excellent condition) and all maintenance aside from oil changes has been at a BMW stealership.
additionally at 150,000 "Inspection I" should be performed (if all maintenance has been done as scheduled). judging by his post it has and this is basic shit like checking belts and fluids and what not.
also as a side note, these cars naturally burn a little bit of oil, so you'll have to check regularly i burn about a quart every ~2 months depending on driving.
PS. ZSP = sport package.
The performance package was available on 2003-2005 330 sedans (330i) and 2004-2006 330 coupes and convertibles (330Ci/330Cic). In 2003, it was only available with the 6-speed manual transmission and WITHOUT the premium package. In 2004, all performance package cars were also available with the automatic (steptronic) transmission as well as the premium package.
Obviously, the Performance Package is a level above the Sport Package, so they're not available together.
Per the BMW press release, this package included the following changes. However, many of these claims have been found to be misleading:
Engine mods (new camshafts, electronics, & lighter flywheel) for 10HP & 8 ft/lb of torque increase & 6800 max RPM (from 6500).
6 speed short throw shifter (for manual transmission equipped cars)
3.07:1 Final drive ratio w/ manual trans instead of the standard 2.91:1. Convertibles retained the already installed 3.07 ratio.
Max Speed Limiter set to 155 mph (instead of 128)
New M suspension, more "sporty" than standard sport package:
Firmer springs (front +6%, rear +8%)
There are no "ZHP" specific springs. The same springs are used for comparably equipped 330's for both the ZSP and the ZHP. In both cases, the spring rate for the post 4/01 build ZSP and ZHP is believed to be slightly less than that of the pre-4/01 ZSP
Firmer shocks (Jounce: front +50%, rear +20%), (Rebound: front +35%, rear -8%)
ZHP does use different dampers than the ZSP. There is a shortage of shock dyno data, but based on the SACHS damping parameter values it is believe the jounce damping is the same but rebound damping is stiffer on the ZHP. Pre-4/01 sport package cars had similar damping values to the ZHP but used the higher grade SACHS "Advantage" dampers rather than the "Super Touring" model
Larger diameter anti-roll bars: 23.5 mm front (v. 23.0), 18.5 mm rear (v. 18.0)
Sway bar diameters are 23.5 mm and 18.0 mm for all post 4/01 build 330's. There is no 18.5 mm rear sway bar offered by BMW for the E46.
More rigid forward bushings
Front Control arm bushings are the same ZHP/ZSP
ZHP control arms are different and use a stiffer ball joint
Lower ride height by 15 mm (.6 inches) utilizing shorter auxiliary springs
Since both the ZSP and ZHP use the same springs, they have the same ride height. Both are 15mm lower than a non-sport E46
-.5 degrees of camber (for a total of -1.1 degrees)
Alignment settings are the same ZSP and ZHP
BMW M exterior trim elements (front & rear fascia, side sills, & trunk lid spoiler)
Special exterior trim: Anthracite (charcoal) headlight & foglight surrounds, High-Gloss
Shadowline (black gloss) trim
Large diameter stainless steel dual exhaust outlets
Extra thick Alcantra steering wheel (later switched to perforated leather)
ZSP Sport Seats
Alcantra & cloth upholstry to replace leatherette and standard trim (leather still optional)
Choice of "Black Cube" or "Silver Cube" interior trim
Anthracite headliner
Red needles on the instrument cluster
Unique 18" Wheels (style 135M), 18x8.0" front, 18x8.5" rear
Wider Tires: 225/40ZR-18 in front and 255/35ZR-18 in the rear.
Quicker steering rack ratio. 13.7:1 versus 15.4:1
All post 4/01 330's use the same part number steering rack. The ratio of this rack has not been confirmed, but it is believed to be different from that used on the 325's
you can cross of sport package. and from the best of my knowledge they all came with heated seats. as for premium package. i don't even know what that is.
if you're on KBB, the price he has this car is at the highend of the KBB value. mine is 2003 with 109k and it said my asking price would be around 12k (in excellent condition) and all maintenance aside from oil changes has been at a BMW stealership.
additionally at 150,000 "Inspection I" should be performed (if all maintenance has been done as scheduled). judging by his post it has and this is basic shit like checking belts and fluids and what not.
also as a side note, these cars naturally burn a little bit of oil, so you'll have to check regularly i burn about a quart every ~2 months depending on driving.
PS. ZSP = sport package.
Last edited by Tito; 09-07-2010 at 09:01 AM.
Thread
Thread Starter
Forum
Replies
Last Post